Category: Steering

System Description Function and Operation Steering Sensor The steering sensor consists of a torque sensor, an in- terface, and the rotation sensor. INPUT SHAFT TORSION BAR SPIRAL GROOVE GUIDE PIN INTERFACE CIRCUIT Torque Sensor The torque sensor converts steering torque input and its direction to voltage signals, in conjunction with the in- terface. A torsional […]

Inspection SHIM STEERING COLUMN ASSEMBLY 6 mm SOCKET BOLT 10 N-m (1.0 kg-m, 7 lb-ft) RETAINING COLLARS Check for damage. 8 mm FLANGE NUTS 16 N-m (1.6 kg-m, 12 Ib-ft) STEERING JOINT BOLTS 22 N-m (2.2 kg-m, 16 Ib-ft) CLIP 8 mm BOLTS 22 N-m (2.2 kg-m, 16 Ib-ft) STEERING JOINT COVER CLAMPS NOTE: • […]

Symptom-to-System Chart Diagnostic Trouble Code (DTC) 17-27 17-29 17-31 17-36 17-38 17-40 Initial diagnosis: Performed right after the engine starts until the EPS indicator light goes off. Regular diagnosis: Continuously performed (under some conditions) after the EPS indicator light goes off until the engine stops. Individual part/system diagnosis: Diagnoses a specific part/system under its operating […]

EPS Control unit Replacement CAUTION: Be careful not to damage the SRS wire harnesses when servicing the control unit. 1. Remove the dashboard lower cover and glove box and disconnect the light connector. 3. Disconnect the connectors from the EPS control unit by removing the wire harness band. EPS CONTROL UNIT 4. Remove the power […]

EPS Control Unit Terminal Arrangement Main Menu Table of Contents EPS Control Unit Terminal Arrangement l 1 ↽ −−∙ 8P CONNECTOR ,I 2 3 4 5 6 7 8 9 1011 121314515161718 WIRE SIDE OF FEMALE TERMINALS VB’ Batteer VD|t_age IG SW: lgnmon swnch Voltage Terminal Wire Terminal sign! . . „umher colo, Terminal „ma […]

Steering Wheel Removal Airbag Removal Store a removed airbag assembly with the pad surface up. If the airbag is improperly stored face down, accidental deployment could propel the unit with enough force to cause serious injury. NOTE: Before removing the steering wheel, make sure the front wheels are straight ahead. SRS components are located in […]

Energy-absorbing Steering Column/Wheel Both the steering column and steering wheel are designed to absorb impact energy during a collision. Steering Wheel The steering wheel absorbs the energy of a collision through the deformation of the spoke portion. Should the impact absorbing capacity of the column side decrease due to the deformation of the vehicle body […]